- About EITEE
- Articles Online
- For Authors
- For Reviewers
- Features
- Subscription & Service
- Personal Center
- Logout
FOLLOWUS
- About EITEE
- Introduction
- Editorial Board
- Corresponding Experts
- Events
- Honors
- Contact Us
- Articles Online
- Current Issue
- Archive
- Special Issues
- Virtual Issues
- Highlights
- In Press
- For Authors
- Submit
- Call for papers
- Guide for Authors
- Ethics & Disclosures
- Fee & Funding
- Downloads
- For Reviewers
- Guide for Reviewers
- Ethics & Disclosures
- Thanks card
- Features
- FITEE Forum
- Engineering Front
- Paper Videos
- Editors’ Corner
- Other Resources
- Subscription & Service
- Subscription
- Services
Torque characteristics in a large permanent magnet synchronous generator with stator radial ventilating air ducts
- 有定子径向通风孔的大型永磁同步发电机的转矩特性
- Frontiers of Information Technology & Electronic Engineering Vol. 17, Issue 8, Pages: 814-824(2016)
- Affiliations：
1College of Electrical Engineering, Zhejiang University, Hangzhou 310027, China
2Power Engineering Centre, Cranfield University, Cranfield MK43 0AL, UK
- Author bio：
E-mail:w.fei@cranfield.ac.uk
- Funds：
DOI：10.1631/FITEE.1500238
CLC： TM351Received：24 July 2015，
Accepted：17 February 2016，
Published：2016-08
- Accepted：
Scan QR Code
He HAO, Wei-zhong FEI, Dong-min MIAO, et al. Torque characteristics in a large permanent magnet synchronous generator with stator radial ventilating air ducts[J]. Frontiers of Information Technology & Electronic Engineering, 2016, 17(8): 814-824.
He HAO, Wei-zhong FEI, Dong-min MIAO, et al. Torque characteristics in a large permanent magnet synchronous generator with stator radial ventilating air ducts[J]. Frontiers of Information Technology & Electronic Engineering, 2016, 17(8): 814-824. DOI： 10.1631/FITEE.1500238.
摘要
目的
2
针对应用于海上风电的大型低速直驱型永磁同步发电机，研究具有径向通风风道定子和分段斜极的转子对于电机转矩特性的影响。
创新点
2
利用二维和三维有限元分析，得到定子通风孔的存在对于电机转矩特性的影响，并且通过对永磁体结构和转子分段斜极的优化，得到其对电机转矩特性的影响，提高电机转矩性能，降低了对机械齿轮的要求。
方法
2
首先，考虑到大型直驱型永磁同步发电机采用的机械齿轮的机械忍耐性受到限制，因此减少电机的转矩脉动具有非常重要的意义，对于海上工作的风力发电机来说尤为如此。接着，针对现有风力发电机，在具有定子通风孔条件下提出了对于电机永磁体形状的优化，并通过二维和三维的有限云分析，得到了其对电机转矩特性的影响。然后，通过提出对电机转子的分段斜极的优化，同样利用二维和三维的有限元分析得到不同转子结构对电机转矩特性的影响。最后，通过分析比较得到不同结构对电机平均转矩、转矩脉动等的影响。
结论
2
针对大容量永磁同步发电机，我们发现定子通风孔不仅会降低电机的平均转矩，还会增加电机的转矩脉动，且电枢电流和转子分段斜极对减少电机的转矩脉动具有非常大的影响。
Abstract
In this study
we investigated the torque characteristics of large low-speed direct-drive permanent magnet synchronous generators with stator radial ventilating air ducts for offshore wind power applications. Magnet shape optimization was used first to improve the torque characteristics using two-dimensional finite element analysis (FEA) in a permanent magnet synchronous generator with a common stator. The rotor step skewing technique was then employed to suppress the impacts of mechanical tolerances and defects
which further improved the torque quality of the machine. Comprehensive three-dimensional FEA was used to evaluate accurately the overall effects of stator radial ventilating air ducts and rotor step skewing on torque features. The influences of the radial ventilating ducts in the stator on torque characteristics
such as torque pulsation and average torque in the machine with and without rotor step skewing techniques
were comprehensively investigated using three-dimensional FEA. The results showed that stator radial ventilating air ducts could not only reduce the average torque but also increase the torque ripple in the machine. Furthermore
the torque ripple of the machine under certain load conditions may even be increased by rotor step skewing despite a reduction in cogging torque.
关键词
Keywords
references
M Ashabani , , , YARI Mohamed . . Multiobjective shape optimization of segmented pole permanentmagnet synchronous machines with improved torque characteristics . . IEEE Trans. Magn. , , 2011 . . 47 ( ( 4 ): ): 795 - - 804 . . DOI: 10.1145/1076034.1076075 http://doi.org/10.1145/1076034.1076075 . .
K Atallah , , , J Wang , , , D Howe . . Torque-ripple minimization in modular permanent-magnet brushless machines . . IEEE Trans. Ind. Appl. , , 2003 . . 39 ( ( 6 ): ): 1689 - - 1695 . . DOI: 10.1109/TIA.2003.818986 http://doi.org/10.1109/TIA.2003.818986 . .
N Bianchi , , , S Bolognani , , , 等 . . Design techniques for reducing the cogging torque in surface-mounted PM motors . . IEEE Trans. Ind. Appl. , , 2002 . . 38 ( ( 5 ): ): 1259 - - 1265 . . DOI: 10.1109/TIA.2002.802989 http://doi.org/10.1109/TIA.2002.802989 . .
B Boukais , , , H Zeroug , , , 等 . . Magnet segmentation for commutation torque ripple reduction in a brushless DC motor drive . . IEEE Trans. Magn. , , 2010 . . 46 ( ( 11 ): ): 3909 - - 3919 . . DOI: 10.1109/TMAG.2010.2057439 http://doi.org/10.1109/TMAG.2010.2057439 . .
HS Chen , , , DG Dorrell , , , MC Tsai , , , 等 . . Design and operation of interior permanent-magnet motors with two axial segments and high rotor saliency . . IEEE Trans. Magn. , , 2010 . . 46 ( ( 9 ): ): 3664 - - 3675 . . DOI: 10.1109/TMAG.2010.2048037 http://doi.org/10.1109/TMAG.2010.2048037 . .
NN Chen , , , SL Ho , , , WN Fu . . Optimization of permanent magnet surface shapes of electric motors for minimization of cogging torque using FEM . . IEEE Trans. Magn. , , 2010 . . 46 ( ( 6 ): ): 2478 - - 2481 . . DOI: 10.1109/TMAG.2010.2044764 http://doi.org/10.1109/TMAG.2010.2044764 . .
WQ Chu , , , ZQ Zhu . . Reduction of on-load torque ripples in permanent magnet synchronous machines by improved skewing . . IEEE Trans. Magn. , , 2013 . . 49 ( ( 7 ): ): 3822 - - 3825 . . DOI: 10.1109/TMAG.2013.2247381 http://doi.org/10.1109/TMAG.2013.2247381 . .
WZ Fei , , , PCK Luk . . An improved model for the back-EMF and cogging torque characteristics of a novel axial flux permanent magnet synchronous machine with a segmental laminated stator . . IEEE Trans. Magn. , , 2009 . . 45 ( ( 10 ): ): 4609 - - 4612 . . DOI: 10.1109/TMAG.2009.2024127 http://doi.org/10.1109/TMAG.2009.2024127 . .
WZ Fei , , , PCK Luk . . A new technique of cogging torque suppression in direct-drive permanent-magnet brushless machines . . IEEE Trans. Ind. Appl. , , 2010 . . 46 ( ( 4 ): ): 1332 - - 1340 . . DOI: 10.1109/TIA.2010.2049551 http://doi.org/10.1109/TIA.2010.2049551 . .
WZ Fei , , , PCK Luk . . Torque ripple reduction of a direct-drive permanent-magnet synchronous machine by material-efficient axial pole pairing . . IEEE Trans. Ind. Electron. , , 2012 . . 59 ( ( 6 ): ): 2601 - - 2611 . . DOI: 10.1109/TIE.2011.2158048 http://doi.org/10.1109/TIE.2011.2158048 . .
WZ Fei , , , PCK Luk , , , JX Shen . . Torque analysis of permanent-magnet flux switching machines with rotor step skewing . . IEEE Trans. Magn. , , 2012 . . 48 ( ( 10 ): ): 2664 - - 2673 . . DOI: 10.1109/TMAG.2012.2198223 http://doi.org/10.1109/TMAG.2012.2198223 . .
WZ Fei , , , PCK Luk , , , D Wu . . Approximate three-dimensional finite element analysis of large permanent magnet synchronous generators with stator radial ventilating ducts . . 2013 . . 39th Annual Conf. of IEEE Industrial Electronics Society . . 7313 - - 7318 . . DOI: 10.1109/IECON.2013.6700349 http://doi.org/10.1109/IECON.2013.6700349 . .
JA Güemes , , , AA Iraolagoitia , , , JI Del Hoyo . . Torque analysis in permanent-magnet synchronous motors: a comparative study . . IEEE Trans. Energy Conv. , , 2011 . . 26 ( ( 1 ): ): 55 - - 63 . . DOI: 10.1109/TEC.2010.2053374 http://doi.org/10.1109/TEC.2010.2053374 . .
SH Han , , , TM Jahns , , , WL Soong . . Torque ripple reduction in interior permanent magnet synchronous machines using stators with odd number of slots per pole pair . . IEEE Trans. Energy Conv. , , 2010 . . 25 ( ( 1 ): ): 118 - - 127 . . DOI: 10.1109/TEC.2009.2033196 http://doi.org/10.1109/TEC.2009.2033196 . .
MS Islam , , , S Mir , , , T Sebastian , , , 等 . . Design consideration of sinusoidally excited permanent-magnet machines for low-torque-ripple applications . . IEEE Trans. Ind. Appl. , , 2005 . . 41 ( ( 4 ): ): 955 - - 962 . . DOI: 10.1109/TIA.2005.851026 http://doi.org/10.1109/TIA.2005.851026 . .
R Islam , , , I Husain , , , A Fardoun . . Permanentmagnet synchronous motor magnet designs with skewing for torque ripple and cogging torque reduction . . IEEE Trans. Ind. Appl. , , 2009 . . 45 ( ( 1 ): ): 152 - - 160 . . DOI: 10.1109/TIA.2008.2009653 http://doi.org/10.1109/TIA.2008.2009653 . .
TM Jahns , , , WL Soong . . Pulsating torque minimization techniques for permanent magnet AC motor drives—a review . . IEEE Trans. Ind. Electron. , , 1996 . . 43 ( ( 2 ): ): 321 - - 330 . . DOI: 10.1109/41.491356 http://doi.org/10.1109/41.491356 . .
R Lateb , , , N Takorabet , , , F Meibody-Tabar . . Effect of magnet segmentation on the cogging torque in surface-mounted permanent-magnet motors . . IEEE Trans. Magn. , , 2006 . . 42 ( ( 3 ): ): 442 - - 445 . . DOI: 10.1109/TMAG.2005.862756 http://doi.org/10.1109/TMAG.2005.862756 . .
T Li , , , G Slemon . . Reduction of cogging torque in permanent magnet motors . . IEEE Trans. Magn. , , 1988 . . 24 ( ( 6 ): ): 2901 - - 2903 . . DOI: 10.1109/20.92282 http://doi.org/10.1109/20.92282 . .
Y Pang , , , ZQ Zhu , , , D Howe , , , 等 . . Self-shielding magnetized vs. shaped parallel-magnetized PM brushless AC motors. . . KIEE Int. Trans. Electr. Mach. Energy Conv. Syst. , , 2005 . . 5-B ( ( 1 ): ): 13 - - 19 . . . .
J Pyrhonen , , , V Ruuskanen , , , J Nerg . . Permanent-magnet length effects in AC machines . . IEEE Trans. Magn. , , 2010 . . 46 ( ( 10 ): ): 3783 - - 3789 . . DOI: 10.1109/TMAG.2010.2050002 http://doi.org/10.1109/TMAG.2010.2050002 . .
V Ruuskanen , , , J Nerg , , , J Pyrhonen . . Effect of lamination stack ends and radial cooling channels on noload voltage and inductances of permanent-magnet synchronous machines . . IEEE Trans. Magn. , , 2011 . . 47 ( ( 11 ): ): 4643 - - 4649 . . DOI: 10.1109/TMAG.2011.2158233 http://doi.org/10.1109/TMAG.2011.2158233 . .
V Ruuskanen , , , J Nerg , , , M Niemelä , , , 等 . . Effect of radial cooling ducts on the electromagnetic performance of the permanent magnet synchronous generators with double radial forced air cooling for direct-driven wind turbines . . IEEE Trans. Magn. , , 2013 . . 49 ( ( 6 ): ): 2974 - - 2981 . . DOI: 10.1109/TMAG.2013.2238679 http://doi.org/10.1109/TMAG.2013.2238679 . .
J Sopanen , , , V Ruuskanen , , , J Nerg . . Dynamic torque analysis of a wind turbine drive train including a direct-driven permanent-magnet generator . . IEEE Trans. Ind. Electron. , , 2011 . . 58 ( ( 9 ): ): 3859 - - 3867 . . DOI: 10.1109/TIE.2010.2087301 http://doi.org/10.1109/TIE.2010.2087301 . .
JA Tapia , , , J Pyrhonen , , , J Puranen , , , 等 . . Optimal design of large permanent magnet synchronous generators . . IEEE Trans. Magn. , , 2013 . . 49 ( ( 1 ): ): 642 - - 650 . . DOI: 10.1109/TMAG.2012.2207907 http://doi.org/10.1109/TMAG.2012.2207907 . .
Y Wang , , , MJ Jin , , , WZ Fei , , , 等 . . Cogging torque reduction in permanent magnet flux-switching machines by rotor teeth axial pairing . . IET Electr. Power Appl. , , 2010 . . 4 ( ( 7 ): ): 500 - - 506 . . DOI: 10.1049/iet-epa.2009.0205 http://doi.org/10.1049/iet-epa.2009.0205 . .
Y Yang , , , X Wang , , , R Zhang . . The optimization of pole arc coefficient to reduce cogging torque in surface-mounted permanent magnet motors . . IEEE Trans. Magn. , , 2006 . . 42 ( ( 4 ): ): 1135 - - 1138 . . DOI: 10.1109/TMAG.2006.871452 http://doi.org/10.1109/TMAG.2006.871452 . .
ZQ Zhu , , , D Howe . . Influence of design parameters on cogging torque in permanent magnet machines . . IEEE Trans. Energy Conv. , , 2000 . . 15 ( ( 4 ): ): 407 - - 412 . . DOI: 10.1109/60.900501 http://doi.org/10.1109/60.900501 . .
ZQ Zhu , , , S Ruangsinchaiwanich , , , D Ishak . . Analysis of cogging torque in brushless machines having nonuniformly distributed stator slots and stepped rotor magnets . . IEEE Trans. Magn. , , 2005 . . 41 ( ( 10 ): ): 3910 - - 3912 . . DOI: 10.1109/TMAG.2005.854968 http://doi.org/10.1109/TMAG.2005.854968 . .
- L-PDFDownload
- Meta-XMLDownload
- BibTeXDownload
- EndnoteDownload
- RefMan Download
- NoteExpressDownload
- NoteFirstDownload
Publicity Resources
Related Articles
Related Author
Related Institution
Chat- Address：Zhejiang University Press, 148 Tianmushan Road, Hangzhou, China Postal code：310028
- Tel：+86-571-88273162 Email：fitee@zju.edu.cn
- Copyright © 2000 - 2025, Zhejiang University Press 京ICP备09064830号-19
京公网安备11010802024621 - It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
- Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.
