基于分形图案蚀刻屏蔽金属提高磁耦合能量传输效率

Qing-feng LI; Shao-bo CHEN; Wei-ming WANG; Hong-wei HAO; Lu-ming LI

doi:10.1631/FITEE.1500114

Your Location：

Home >

Browse articles >

基于分形图案蚀刻屏蔽金属提高磁耦合能量传输效率

常规文章 | Updated：2022-05-19

- 基于分形图案蚀刻屏蔽金属提高磁耦合能量传输效率
- Improving the efficiency of magnetic coupling energy transfer by etching fractal patterns in the shielding metals
- 信息与电子工程前沿（英文） 2016年17卷第1期页码：74-82
- Affiliations：
  
  1School of Aerospace, Tsinghua University, Beijing 100084, China
  2National Engineering Laboratory for Neuromodulation, Beijing 100084, China
  3Center of Epilepsy, Beijing Institute for Brain Disorders, Beijing 100084, China
- Author bio：
  
  E-mail:lqf05@mails.tsinghua.edu.cn
  E-mail:lilm@tsinghua.edu.cn
- Funds：
  
  Project supported by the National Natural Science Foundation of China (No. 51125028) and the National Key Technology R & D Program of China (No. 2011BAI12B07)
- DOI：10.1631/FITEE.1500114
  中图分类号： TN992
- 收稿：2015-04-09，
  
  录用：2015-8-5，
  
  纸质出版：2016-01
- Accepted：
Scan QR Code
基于分形图案蚀刻屏蔽金属提高磁耦合能量传输效率[J]. 信息与电子工程前沿（英文）, 2016,17(1):74-82.

Qing-feng LI, Shao-bo CHEN, Wei-ming WANG, et al. Improving the efficiency of magnetic coupling energy transfer by etching fractal patterns in the shielding metals[J]. Frontiers of Information Technology & Electronic Engineering, 2016, 17(1): 74-82.
基于分形图案蚀刻屏蔽金属提高磁耦合能量传输效率[J]. 信息与电子工程前沿（英文）, 2016,17(1):74-82. DOI： 10.1631/FITEE.1500114.

Qing-feng LI, Shao-bo CHEN, Wei-ming WANG, et al. Improving the efficiency of magnetic coupling energy transfer by etching fractal patterns in the shielding metals[J]. Frontiers of Information Technology & Electronic Engineering, 2016, 17(1): 74-82. DOI： 10.1631/FITEE.1500114.

摘要

目的

针对磁耦合能量传输中屏蔽金属的涡流效应导致传输效率降低的问题，提出一种可有效抑制金属涡流效应的方法，从而提高能量传输效率。

创新点

提出在屏蔽金属上蚀刻具备分形特征的几何图案的方法。该方法改变了磁耦合能量传输中金属表面的涡流分布，有效抑制了其涡流效应，能量传输效率接近无金属介质时的水平。

方法

首先，利用电磁仿真方法建立模拟层状金属屏蔽的磁耦合能量传输模型（图1）。基于仿真模型找出可有效抑制涡流效应的蚀刻图案的特征。其次，在满足这些特征的条件下，提出并比较几种不同分形图案（图4）蚀刻金属后的能量传输性能，选择性能最好的图案（图4g）计算其频率响应，并探讨其抑制涡流效应的机制。然后，仿真研究了多层金属应用背景下，采用分形图案蚀刻金属以提高传输效率的方法。最后，建立仿真模型对应的实验平台，对可有效抑制金属涡流效应的图案特征，以及多层金属应用下用分形图案蚀刻方法抑制涡流效应的结果进行实验验证。

结论

针对磁耦合能量传输中普遍存在的层状金属应用环境，提出了采用分形图案蚀刻金属的方法，有效抑制了金属涡流效应，提高能量传输效率。

Abstract

Thin metal sheets are often located in the coupling paths of magnetic coupling energy transfer (MCET) systems. Eddy currents in the metals reduce the energy transfer efficiency and can even present safety risks. This paper describes the use of etched fractal patterns in the metals to suppress the eddy currents and improve the efficiency. Simulation and experimental results show that this approach is very effective. The fractal patterns should satisfy three features

namely

breaking the metal edge

etching in the high-intensity magnetic field region

and etching through the metal in the thickness direction. Different fractal patterns lead to different results. By altering the eddy current distribution

the fractal pattern slots reduce the eddy current losses when the metals show resistance effects and suppress the induced magnetic field in the metals when the metals show inductance effects. Fractal pattern slots in multilayer high conductivity metals (e.g.

Cu) reduce the induced magnetic field intensity significantly. Furthermore

transfer power

transfer efficiency

receiving efficiency

and eddy current losses all increase with the increase of the number of etched layers. These results can benefit MCET by efficient energy transfer and safe use in metal shielded equipment.

关键词

Keywords

references

J Albesa , , , M Gasulla . . Inductive power transfer for autonomous sensors in presence of metallic structures . . IEEE Int Instrumentation and Measurement Technology Conf , , 2012 . . 664 - - 669 . . DOI: 10.1109/I2MTC.2012.6229658 http://doi.org/10.1109/I2MTC.2012.6229658 . .

DB Geselowtiz , , , QTN Hoang , , , RP Gaumond . . The effects of metals on a transcutaneous energy transmission system . . IEEE Trans. Biomed. Eng , , 1992 . . 39 ( ( 9 ): ): 928 - - 934 . . DOI: 10.1109/10.256426 http://doi.org/10.1109/10.256426 . .

JS Ho , , , AJ Yeh , , , E Neofytou . . Wireless power transfer to deep-tissue microimplants . . PNAS , , 2014 . . 111 ( ( 22 ): ): 7974 - - 7979 . . DOI: 10.1073/pnas.1403002111 http://doi.org/10.1073/pnas.1403002111 . .

M Kufa , , , Z Raida . . Lowpass filter with reduced fractal defected ground structure . . Electron. Lett , , 2013 . . 49 ( ( 3 ): ): 199 - - 201 . . DOI: 10.1049/el.2012.3473 http://doi.org/10.1049/el.2012.3473 . .

A Kurs , , , A Karalis , , , R Moffatt . . Wireless power transfer via strongly coupled magnetic resonances . . Science , , 2007 . . 317 ( ( 5834 ): ): 83 - - 86 . . DOI: 10.1126/science.1143254 http://doi.org/10.1126/science.1143254 . .

RD Lovik , , , JP Abraham , , , EM Sparrow . . Surrogate human tissue temperatures resulting from misalignment of antenna and implant during recharging of a neuromodulation device . . Neuromodulation , , 2011 . . 14 ( ( 6 ): ): 501 - - 511 . . DOI: 10.1111/j.1525-1403.2011.00396.x http://doi.org/10.1111/j.1525-1403.2011.00396.x . .

S Rani , , , AP Singh . . Modified Koch fractal antenna with asymmetrical ground plane for multi and UWB applications . . Int. J. Appl. Electrom , , 2013 . . 42 ( ( 2 ): ): 259 - - 267 . . DOI: 10.3233/JAE-131662 http://doi.org/10.3233/JAE-131662 . .

N.J Siakavellas . . Two simple models for analytical calculation of eddy currents in thin conducting plates . . IEEE Trans. Magn , , 1997 . . 33 ( ( 3 ): ): 2245 - - 2257 . . DOI: 10.1109/20.573839 http://doi.org/10.1109/20.573839 . .

DD Ye , , , GZ Yan , , , KD Wang . . Development of a non-cable whole tectorial membrane micro-robot for an endoscope . . J. Zhejiang Univ.-Sci. A , , 2008 . . 9 ( ( 8 ): ): 1141 - - 1149 . . DOI: 10.1631/jzus.A0720074 http://doi.org/10.1631/jzus.A0720074 . .

X Yu , , , T Skauli , , , B Skauli . . Wireless power transfer in the presence of metallic plates: experimental results . . AIP Adv , , 2013 . . 3 ( ( 6 ): ): 062102 DOI: 10.1063/1.4809665 http://doi.org/10.1063/1.4809665 . .

lH Zang , , , A Fuchs , , , T Bretterklieber . . Wireless communication and power supply strategy for sensor applications within closed metal walls . . IEEE Trans. Instrum. Meas , , 2010 . . 59 ( ( 6 ): ): 1686 - - 1692 . . DOI: 10.1109/TIM.2009.2026602 http://doi.org/10.1109/TIM.2009.2026602 . .

浏览量

Downloads

CSCD

文章被引用时，请邮件提醒。

Submit

工具集

关联资源

暂无数据