一种新颖的用于宽输入电压范围的LLC谐振变换器的变模态控制策略

林辉品; 靳晓光; 解良; 胡进; 吕征宇

doi:10.1631/FITEE.1600029

Your Location：

Home >

Browse articles >

一种新颖的用于宽输入电压范围的LLC谐振变换器的变模态控制策略

常规文章 | Updated：2022-05-19

- 一种新颖的用于宽输入电压范围的LLC谐振变换器的变模态控制策略
- A new variable-mode control strategy for LLC resonant converters operating in a wide input voltage range
- 信息与电子工程前沿（英文） 2017年18卷第3期页码：410-422
- Affiliations：
  
  College of Electrical Engineering, Zhejiang University, Hangzhou 310027, China
- Author bio：
- Funds：
  
  Project supported by the National Natural Science Foundation of China (Nos. 51177148 and 51407151)
- DOI：10.1631/FITEE.1600029
  中图分类号： TM923.61
- 收稿：2016-01-20，
  
  录用：2017-11-10，
  
  纸质出版：2017-03
- Accepted：
Scan QR Code
林辉品, 靳晓光, 解良, 等. 一种新颖的用于宽输入电压范围的LLC谐振变换器的变模态控制策略[J]. 信息与电子工程前沿（英文）, 2017,18(3):410-422.

Hui-pin LIN, Xiao-guang JIN, Liang XIE, et al. A new variable-mode control strategy for LLC resonant converters operating in a wide input voltage range[J]. Frontiers of Information Technology & Electronic Engineering, 2017, 18(3): 410-422.
林辉品, 靳晓光, 解良, 等. 一种新颖的用于宽输入电压范围的LLC谐振变换器的变模态控制策略[J]. 信息与电子工程前沿（英文）, 2017,18(3):410-422. DOI： 10.1631/FITEE.1600029.

Hui-pin LIN, Xiao-guang JIN, Liang XIE, et al. A new variable-mode control strategy for LLC resonant converters operating in a wide input voltage range[J]. Frontiers of Information Technology & Electronic Engineering, 2017, 18(3): 410-422. DOI： 10.1631/FITEE.1600029.

摘要

本文提出了一种新颖的适用于LLC谐振变换器的混合模态控制策略，可以使得LLC谐振变换器输入宽电压范围。这种控制策略结合了全桥LLC谐振变换器，半桥LLC谐振变换器，变频控制和变脉宽控制的优点。在这种控制策略下，不同的输入电压决定了不同的电路工作模态。当输入电压很低的时候，电路采用了全桥电路和变频控制（FB_VF模态）。当输入电压升高到一定值，电路切换到全桥电路和移相控制（FB_PS模态）。当输入电压进一步上升时，电路切换到半桥电路和变频控制（FB_VF模态）。这种电路模态的切换是由数字信号处理器（digital signal processor

DSP）来实现的，不需要外加辅助电路，只需要修改一下软件。从轻载到重载下，LLC谐振变换器的原边MOSFET可以实现零电压开通（zero-voltage switching

ZVS），副边二极管可以实现零电流关断（zero-current switching

ZCS）。本文用一个额定功率300 W，输出电压450 V的LLC，输入电压20 V到120 V的谐振变换器的样机验证了这个优化的控制策略。实验结果显示，在这种控制策略下，变换器的最大工作效率可以达到95.7%，并且输入电压范围扩大了3倍。

Abstract

This paper proposes a new variable-mode control strategy that is applicable for LLC resonant converters operating in a wide input voltage range. This control strategy incorporates advantages from full-bridge LLC resonant converters

half-bridge LLC resonant converters

variable-frequency control mode

and phase-shift control mode. Under this control strategy

different input voltages determine the different operating modes of the circuit. When the input voltage is very low

it works in a full-bridge circuit and variable frequency mode (FB_VF mode). When the input voltage rises to a certain level

it shifts to a full-bridge circuit and phase-shifting control mode (FB_PS mode). When the input voltage further increases

it shifts into a half-bridge circuit and variable frequency mode (HB_VF mode). Such shifts are enabled by the digital signal processor (DSP)

which means that no auxiliary circuit is needed

just a modification of the software. From light load to heavy load

the primary MOSFET for the LLC resonant converter can realize zero-voltage switching (ZVS)

and the secondary rectifier diode can realize zero-current switching (ZCS). With an LLC resonant converter prototype with a 300 W rated power and a 450 V output voltage

as well as a resonant converter with 20-120 V input voltage

the experiments verified the proposed control strategy. Experimental results showed that under this control strategy

the maximum converter efficiency reaches 95.7% and the range of the input voltage expands threefold.

关键词

Keywords

references

W Chen , , , XY Hong , , , SR Wang , , , 等 . . High efficiency soft-switched step-up DC-DC converter with hybrid mode LLC+C resonant tank . . 2010 . . 25th Annual IEEE Applied Power Electronics Conf. and Exposition . . 1358 - - 1364 . . DOI: 10.1109/APEC.2010.5433406 http://doi.org/10.1109/APEC.2010.5433406 . .

X Fang , , , HB Hu , , , J Shen , , , 等 . . An optimal design of the LLC resonant converter based on peak gain estimation . . 2012 . . 27th Annual IEEE Applied Power Electronics Conf. and Exposition . . 1286 - - 1291 . . DOI: 10.1109/APEC.2012.6165984 http://doi.org/10.1109/APEC.2012.6165984 . .

Y Fang , , , DH Xu , , , YJ Zhang , , , 等 . . Design of high power density LLC resonant converter with extra wide input range . . 2007 . . 22nd Annual IEEE Applied Power Electronics Conf . . 976 - - 981 . . DOI: 10.1109/APEX.2007.357633 http://doi.org/10.1109/APEX.2007.357633 . .

S Hamamura , , , T Ninomiya , , , M Yamamoto , , , 等 . . Combined PWM and PFM control for universal line voltage of a piezoelectric transformer off-line converter . . IEEE Trans. Power Electron. , , 2003 . . 18 ( ( 1 ): ): 270 - - 277 . . DOI: 10.1109/TPEL.2002.807177 http://doi.org/10.1109/TPEL.2002.807177 . .

J Hu , , , HP Lin , , , ZY Lu , , , 等 . . Flexible resonant tank for a combined converter to achieve an HPS and LED compatible driver . . Front. Inform. Technol. Electron. Eng. , , 2015 . . 16 ( ( 8 ): ): 679 - - 693 . . DOI: 10.1631/FITEE.1500054 http://doi.org/10.1631/FITEE.1500054 . .

J Jang , , , M Joung , , , B Choi , , , 等 . . Dynamic analysis and control design of optocoupler-isolated LLC series resonant converters with wide input and load variations . . IET Power Electron. , , 2012 . . 5 ( ( 6 ): ): 755 - - 764 . . DOI: 10.1049/iet-pel.2011.0289 http://doi.org/10.1049/iet-pel.2011.0289 . .

ZH Jiang . . Power management of hybrid photovoltaic—fuel cell power systems . . 2006 . . IEEE Power Engineering Society General Meeting . . 3458 - - 3463 . . DOI: 10.1109/PES.2006.1709000 http://doi.org/10.1109/PES.2006.1709000 . .

JH Jung , , , JG Kwon . . Theoretical analysis and optimal design of LLC resonant converter . . 2007 . . European Conf. on Power Electronics and Applications . . 1134 - - 1143 . . DOI: 10.1109/EPE.2007.4417639 http://doi.org/10.1109/EPE.2007.4417639 . .

ZG Liang , , , R Guo , , , GY Wang , , , 等 . . A new wide input range high efficiency photovoltaic inverter . . 2010 . . IEEE Energy Conversion Congress and Exposition . . 2937 - - 2943 . . DOI: 10.1109/ECCE.2010.5618217 http://doi.org/10.1109/ECCE.2010.5618217 . .

BR Lin , , , YB Nian , , , TY Shiau . . Resonant converter with fixed frequency control . . 2013 . . IEEE Region 10 Conf. TENCON . . 1 - - 6 . . DOI: 10.1109/TENCON.2013.6718908 http://doi.org/10.1109/TENCON.2013.6718908 . .

A Rajaei , , , M Mohamadian , , , AY Varjani . . Vienna-rectifier-based direct torque control of PMSG for wind energy application . . IEEE Trans. Ind. Electron. , , 2013 . . 60 ( ( 7 ): ): 2919 - - 2929 . . DOI: 10.1109/TIE.2012.2227905 http://doi.org/10.1109/TIE.2012.2227905 . .

RL Steigerwald . . A comparison of half-bridge resonant converter topologies . . IEEE Trans. Power Electron. , , 1988 . . 3 ( ( 2 ): ): 174 - - 182 . . DOI: 10.1109/63.4347 http://doi.org/10.1109/63.4347 . .

SH Song , , , SI Kang , , , NK Hahm . . Implementation and control of grid connected AC-DC-AC power converter for variable speed wind energy conversion systems . . 2003 . . 18th Annual IEEE Applied Power Electronics Conf. and Exposition . . 154 - - 158 . . DOI: 10.1109/APEC.2003.1179207 http://doi.org/10.1109/APEC.2003.1179207 . .

J Tian , , , C Su , , , M Soltani , , , 等 . . Active power dispatch method for a wind farm central controller considering wake effect . . 2014 . . 40th Annual Conf. of the IEEE Industrial Electronics Society, IECON . . 5450 - - 5456 . . DOI: 10.1109/IECON.2014.7049333 http://doi.org/10.1109/IECON.2014.7049333 . .

GR Walker , , , JC Pierce . . PhotoVoltaic DC-DC module integrated converter for novel cascaded and bypass grid connection topologies—design and optimisation . . 2006 . . 37th IEEE Power Electronics Specialists Conf. Records . . 1767 - - 1773 . . DOI: 10.1109/PESC.2006.1712242 http://doi.org/10.1109/PESC.2006.1712242 . .

GR Walker , , , PC Sernia . . Cascaded DC-DC converter connection of photovoltaic modules . . IEEE Trans. Power Electron. , , 2004 . . 19 ( ( 4 ): ): 1130 - - 1139 . . DOI: 10.1109/TPEL.2004.830090 http://doi.org/10.1109/TPEL.2004.830090 . .

CX Wang , , , ZX Lu , , , Y Qiao . . A consideration of the wind power benefits in day-ahead scheduling of wind-coal intensive power systems . . IEEE Trans. Power Syst. , , 2013 . . 28 ( ( 1 ): ): 236 - - 245 . . DOI: 10.1109/TPWRS.2012.2205280 http://doi.org/10.1109/TPWRS.2012.2205280 . .

B Yang . . Topology Investigation of Front End DC/DC Converter for Distributed Power System . . 2003 . . : Blacksburg, USA : Virginia Polytechnic Institute and State University , , PhD Thesis . .

Z Zhang , , , O C Thomsen , , , M A E Andersen . . A DC-DC converter with wide input voltage range for fuel cell and supercapacitor application . . 2009 . . Int. Conf. on Power Electronics and Drive Systems . . 1324 - - 1329 . . DOI: 10.1109/PEDS.2009.5385904 http://doi.org/10.1109/PEDS.2009.5385904 . .

浏览量

Downloads

CSCD

文章被引用时，请邮件提醒。

Submit

工具集

关联资源

暂无数据