变频电机驱动系统中电缆对共模电流影响研究

谢鹏康; 陆佳政; 陈国柱; 陈恒林

doi:10.1631/FITEE.1601518

Your Location：

Home >

Browse articles >

变频电机驱动系统中电缆对共模电流影响研究

常规文章 | Updated：2022-05-19

- 变频电机驱动系统中电缆对共模电流影响研究
- Influence of motor cable on common-mode currents in an inverter-fed motor drive system
- 信息与电子工程前沿（英文） 2018年19卷第2期页码：273-284
- Affiliations：
  
  College of Electrical Engineering, Zhejiang University, Hangzhou 310027, China
  State Key Laboratory of Disaster Prevention & Reduction for Power Grid Transmission and Distribution Equipment, State Grid Hunan Electric Power Corporation Disaster Prevention & Reduction Center, Changsha 410007, China
- Author bio：
  
  Heng-lin CHEN, E-mail: henglin@zju.edu.cn
- Funds：
  
  Project supported by the National Natural Science Foundation of China (No. 51577172)
- DOI：10.1631/FITEE.1601518
  中图分类号： TM12
- 收稿：2016-09-03，
  
  修回：2018-;2-15，
  
  纸质出版：2018-02
- Accepted：
Scan QR Code
谢鹏康, 陆佳政, 陈国柱, 等. 变频电机驱动系统中电缆对共模电流影响研究[J]. 信息与电子工程前沿（英文）, 2018,19(2):273-284.

Peng-kang XIE, Jia-zheng LU, Guo-zhu CHEN, et al. Influence of motor cable on common-mode currents in an inverter-fed motor drive system[J]. Frontiers of Information Technology & Electronic Engineering, 2018, 19(2): 273-284.
谢鹏康, 陆佳政, 陈国柱, 等. 变频电机驱动系统中电缆对共模电流影响研究[J]. 信息与电子工程前沿（英文）, 2018,19(2):273-284. DOI： 10.1631/FITEE.1601518.

Peng-kang XIE, Jia-zheng LU, Guo-zhu CHEN, et al. Influence of motor cable on common-mode currents in an inverter-fed motor drive system[J]. Frontiers of Information Technology & Electronic Engineering, 2018, 19(2): 273-284. DOI： 10.1631/FITEE.1601518.

摘要

由电缆连接的感应电动机驱动系统广泛应用于工业应用领域。然而，功率器件的高频开关在操作过程中会产生共模电压，从而导致电机驱动系统中出现严重的共模电流。在驱动系统中通过电缆和电机的共模电流可以引起周围电子设备的电磁干扰，缩短感应电动机的寿命。因此，有必要对电机驱动系统中的共模电流进行分析。本文建立了无屏蔽和屏蔽电缆的高频模型，考虑了电缆的频率相关效应和互感效应。采用有限元法提取电力电缆参数，并进行验证。介绍了异步电动机和逆变器的高频模型，得到电机和逆变器端子上的共模电流，分析了电缆长度和电缆类型对共模电流的影响。实验结果与模型预测的共模电流有较好一致性。

Abstract

Induction motor drive systems fed by cables are widely used in industrial applications. However

high-frequency switching of power devices will cause common-mode (CM) voltages during operation

leading to serious CM currents in the motor drive systems. CM currents through the cables and motors in the drive systems can cause electromagnetic interference (EMI) with the surrounding electronic equipment and shorten the life of induction motors. Therefore

it is necessary to analyze the CM currents in motor drive systems. In this paper

high-frequency models of unshielded and shielded power cables are formulated. The frequency-dependent effects and mutual inductances of the cables are taken into account. The power cable parameters are extracted by the finite element method and validated by measurements. High-frequency models of induction motors and inverters are introduced from existing works. The CM currents at the motor and inverter terminals are obtained

and the influence of the cable length and cable type on the CM currents is analyzed. There is a good agreement between the experimental results and the CM currents predicted by the proposed models.

关键词

Keywords

references

S Amarir , , , K Al-Haddad . . A modeling technique to analyze the impact of inverter supply voltage and cable length on industrial motor-drives . . IEEE Trans Power Electron , , 2008 . . 23 ( ( 2 ): ): 753 - - 762 . . DOI: 10.1109/TPEL.2007.915773 http://doi.org/10.1109/TPEL.2007.915773 . .

S Cristina , , , M Feliziani . . A finite element technique for multiconductor cable parameters calculation . . IEEE Trans Magn , , 1989 . . 25 ( ( 4 ): ): 2986 - - 2988 . . DOI: 10.1109/20.34346 http://doi.org/10.1109/20.34346 . .

H de Paula , , , DA de Andrade , , , ML Ribeiro Chaves , , , 等 . . Methodology for cable modeling and simulation for high-frequency phenomena studies in PWM motor drives . . IEEE Trans Power Electron , , 2008 . . 23 ( ( 2 ): ): 744 - - 752 . . DOI: 10.1109/TPEL.2007.915759 http://doi.org/10.1109/TPEL.2007.915759 . .

JM Erdman , , , RJ Kerkman , , , DW Schlegel , , , 等 . . Effect of PWM inverters on AC motor bearing currents and shaft voltages . . IEEE Trans Ind Appl , , 1996 . . 32 ( ( 2 ): ): 250 - - 259 . . DOI: 10.1109/28.491472 http://doi.org/10.1109/28.491472 . .

B Hafez , , , AS Abdel-Khalik , , , AM Massoud , , , 等 . . Single-sensor-based three-phase permanent-magnet synchronous motor drive system with Luenberger observers for motor line current reconstruction . . IEEE Trans Ind Appl , , 2014 . . 50 ( ( 4 ): ): 2602 - - 2613 . . DOI: 10.1109/TIA.2013.2296625 http://doi.org/10.1109/TIA.2013.2296625 . .

SK Hoseini , , , J Adabi , , , A Sheikholeslami . . Predictive modulation schemes to reduce common-mode voltage in three-phase inverters-fed AC drive systems . . IET Power Electron , , 2014 . . 7 ( ( 4 ): ): 840 - - 849 . . DOI: 10.1049/iet-pel.2013.0182 http://doi.org/10.1049/iet-pel.2013.0182 . .

D Jiang , , , F Wang , , , J Xue . . PWM impact on CM noise and AC CM choke for variable-speed motor drives . . IEEE Trans Ind Appl , , 2013 . . 49 ( ( 2 ): ): 963 - - 972 . . DOI: 10.1109/TIA.2013.2243394 http://doi.org/10.1109/TIA.2013.2243394 . .

RJ Kerkman , , , D Leggate , , , GL Skibinski . . Interaction of drive modulation and cable parameters on AC motor transients . . IEEE Trans Ind Appl , , 1997 . . 33 ( ( 3 ): ): 722 - - 731 . . DOI: 10.1109/28.585863 http://doi.org/10.1109/28.585863 . .

LM Liu , , , H Li , , , SH Hwang , , , 等 . . An energy-efficient motor drive with autonomous power regenerative control system based on cascaded multilevel inverters and segmented energy storage . . IEEE Trans Ind Appl , , 2013 . . 49 ( ( 1 ): ): 178 - - 188 . . DOI: 10.1109/TIA.2012.2229687 http://doi.org/10.1109/TIA.2012.2229687 . .

XY Lu , , , SX Zhang , , , C Liu , , , 等 . . Modeling of common-mode current in motor cable of inverter-fed motor drive system . . Asia-Pacific Int Symp on Electromagnetic Compatibility , , 2016 . . p.511 - - 514 . . DOI: 10.1109/APEMC.2016.7522783 http://doi.org/10.1109/APEMC.2016.7522783 . .

J Luszcz . . Broadband modeling of motor cable impact on common mode currents in VFD . . IEEE Int Symp on Industrial Electronics , , 2011 . . p.538 - - 543 . . DOI: 10.1109/ISIE.2011.5984215 http://doi.org/10.1109/ISIE.2011.5984215 . .

J Luszcz . . AC motor feeding cable consequences on EMC performance of ASD . . IEEE Int Symp on Electromagnetic Compatibility , , 2013 . . p.248 - - 252 . . DOI: 10.1109/ISEMC.2013.6670418 http://doi.org/10.1109/ISEMC.2013.6670418 . .

O Magdun , , , A Binder . . High-frequency induction machine modeling for common mode current and bearing voltage calculation . . IEEE Trans Ind Appl , , 2014 . . 50 ( ( 3 ): ): 1780 - - 1790 . . DOI: 10.1109/TIA.2013.2284301 http://doi.org/10.1109/TIA.2013.2284301 . .

O Magdun , , , A Binder , , , C Purcarea , , , 等 . . Modeling of asymmetrical cables for an accurate calculation of common mode ground currents . . IEEE Energy Conversion Congress and Exposition , , 2009 . . p.1075 - - 1082 . . DOI: 10.1109/ECCE.2009.5316467 http://doi.org/10.1109/ECCE.2009.5316467 . .

M Moreau , , , N Idir , , , P Le Moigne . . Modeling of conducted EMI in adjustable speed drives . . IEEE Trans Electromagn Compat , , 2009 . . 51 ( ( 3 ): ): 665 - - 672 . . DOI: 10.1109/TEMC.2009.2025269 http://doi.org/10.1109/TEMC.2009.2025269 . .

AF Moreira , , , TA Lipo , , , G Venkataramanan , , , 等 . . High-frequency modeling for cable and induction motor overvoltage studies in long cable drives . . IEEE Trans Ind Appl , , 2002 . . 38 ( ( 5 ): ): 1297 - - 1306 . . DOI: 10.1109/TIA.2002.802920 http://doi.org/10.1109/TIA.2002.802920 . .

C Purcarea , , , P Mutschler , , , O Magdun , , , 等 . . Time domain simulation models for inverter-cable-motor systems in electrical drives . . 13 th European Conf on Power Electronics and Applications , , 2009 . . p.1 - - 10 . . . .

AS Saini , , , MS Nakhla , , , R Achar . . Generalized time-domain adjoint sensitivity analysis of distributed MTL networks . . IEEE Trans Microw Theory Tech , , 2012 . . 60 ( ( 11 ): ): 3359 - - 3368 . . DOI: 10.1109/TMTT.2012.2214053 http://doi.org/10.1109/TMTT.2012.2214053 . .

SK Tseng , , , CC Tseng , , , TH Liu , , , 等 . . Wide-range adjustable speed control method for dual-motor drive systems . . IET Electr Power Appl , , 2015 . . 9 ( ( 2 ): ): 107 - - 116 . . DOI: 10.1049/iet-epa.2013.0291 http://doi.org/10.1049/iet-epa.2013.0291 . .

G Vidmar , , , D Miljavec . . A universal high-frequency three-phase electric-motor model suitable for the delta-and star-winding connections . . IEEE Trans Power Electron , , 2015 . . 30 ( ( 8 ): ): 4365 - - 4376 . . DOI: 10.1109/TPEL.2014.2352452 http://doi.org/10.1109/TPEL.2014.2352452 . .

LW Wang , , , CNM Ho , , , F Canales , , , 等 . . High-frequency modeling of the long-cable-fed induction motor drive system using TLM approach for predicting overvoltage transients . . IEEE Trans Power Electron , , 2010 . . 25 ( ( 10 ): ): 2653 - - 2664 . . DOI: 10.1109/TPEL.2010.2047027 http://doi.org/10.1109/TPEL.2010.2047027 . .

Y Weens , , , N Idir , , , R Bausiere , , , 等 . . Modeling and simulation of unshielded and shielded energy cables in frequency and time domains . . IEEE Trans Magn , , 2006 . . 42 ( ( 7 ): ): 1876 - - 1882 . . DOI: 10.1109/TMAG.2006.874306 http://doi.org/10.1109/TMAG.2006.874306 . .

浏览量

Downloads

CSCD

文章被引用时，请邮件提醒。

Submit

工具集

关联资源

暂无数据