具有双支路交错拓扑结构和轻载效率优化模式的大电流、高集成度开关电容分压器

刘胜; 赵梦恋; 杨朝; 吴皓楠; 吴晓波

doi:10.1631/FITEE.2000404

Your Location：

Home >

Browse articles >

具有双支路交错拓扑结构和轻载效率优化模式的大电流、高集成度开关电容分压器

常规文章 | Updated：2022-04-19

- 具有双支路交错拓扑结构和轻载效率优化模式的大电流、高集成度开关电容分压器
  Enhanced Publication
- A large-current, highly integrated switched-capacitor divider with a dual-branch interleaved topology and light load efficiency improvement
- 信息与电子工程前沿（英文） 2022年23卷第2期页码：317-327
- Affiliations：
  
  1.College of Electrical Engineering, Zhejiang University, Hangzhou310027, China
  2.College of Information Science and Electronic Engineering, Zhejiang University, Hangzhou310027, China
- Author bio：
  
  E-mail: liusheng_0827@zju.edu.cn;
  ‡Corresponding author
- Funds：
  
  Zhejiang Provincial Natural Science Foundation of China(LY18F040001)
- DOI：10.1631/FITEE.2000404
  中图分类号： TN433
- 收稿：2020-08-11，
  
  录用：2021-01-18，
  
  网络出版：2022-01-24，
  
  纸质出版：2022-02-0
- Accepted：
Scan QR Code
刘胜, 赵梦恋, 杨朝, 等. 具有双支路交错拓扑结构和轻载效率优化模式的大电流、高集成度开关电容分压器[J]. 信息与电子工程前沿（英文）, 2022,23(2):317-327.

Sheng LIU, Menglian ZHAO, Zhao YANG, et al. A large-current, highly integrated switched-capacitor divider with a dual-branch interleaved topology and light load efficiency improvement[J]. Frontiers of Information Technology & Electronic Engineering, 2022, 23(2): 317-327.
刘胜, 赵梦恋, 杨朝, 等. 具有双支路交错拓扑结构和轻载效率优化模式的大电流、高集成度开关电容分压器[J]. 信息与电子工程前沿（英文）, 2022,23(2):317-327. DOI： 10.1631/FITEE.2000404.

Sheng LIU, Menglian ZHAO, Zhao YANG, et al. A large-current, highly integrated switched-capacitor divider with a dual-branch interleaved topology and light load efficiency improvement[J]. Frontiers of Information Technology & Electronic Engineering, 2022, 23(2): 317-327. DOI： 10.1631/FITEE.2000404.

摘要

由于无磁且容易实现高集成度，开关电容（SC）变换器作为一种直流变压器在现代电子领域具有广泛应用前景。然而，设计具有大电流和高功率的SC变换器仍面临挑战。本文提出一种双支路SC分压器拓扑，并通过集成电路（IC）得以实现。所设计SC变换器能驱动大电流负载，将其使用范围扩展至大功率应用场合。该SC变换器具有1/2的恒定变换比，其双支路交错操作方式可确保输入电流的连续性。此外，提出一种使用电容耦合型浮动电压电平转换器的片上栅极驱动方法有效驱动全NMOS功率链。通过自供电结构，飞电容器本身也是用于栅极驱动的自举电容器，从而减少所需元器件数量。采用数字调制方式，在轻载时自动降低开关频率以提高效率。所设计SC变换器IC使用180 nm三阱BCD工艺制造。实验结果证明了所提双支路交错操作方式和自供电栅极驱动方法的有效性。所设计SC变换器可在5至12 V的输入电压下驱动高达4 A的负载电流，功率效率高达96.5％。在轻负载条件下，使用所提优化方法，电源效率提高了30％。

Abstract

Because it is magnet-free and can achieve a high integration level

the switched-capacitor (SC) converter acting as a direct current transformer has many promising applications in modern electronics. However

designing an SC converter with large current capability and high power efficiency is still challenging. This paper proposes a dual-branch SC voltage divider and presents its integrated circuit (IC) implementation. The designed SC converter is capable of driving large current load

thus widening the use of SC converters to high-power applications. This SC converter has a constant conversion ratio of 1/2 and its dual-branch interleaved operation ensures a continuous input current. An effective on-chip gate-driving method using a capacitively coupled floating-voltage level shifter is proposed to drive the all-NMOS power train. Due to the self-powered structure

the flying capacitor itself is also a bootstrap capacitor for gate driving and thus reduces the number of needed components. A digital frequency modulation method is adopted and the switching frequency decreases automatically at light load to improve light load efficiency. The converter IC is implemented using a 180 nm triple-well BCD process. Experimental results verify the effectiveness of the dual-branch interleaved operation and the self-powered gate-driving method. The proposed SC divider can drive up to 4 A load current with 5–12 V input voltage and its power efficiency is as high as 96.5%. At light load

using the proposed optimization method

the power efficiency is improved by 30%.

关键词

Keywords

references

Andersen TM , Krismer F , Kolar JW , et al. , 2017 . A 10 W on-chip switched capacitor voltage regulator with feedforward regulation capability for granular microprocessor power delivery . IEEE Trans Power Electron , 32 ( 1 ): 378 - 393 . doi: 10.1109/TPEL.2016.2530745 http://doi.org/10.1109/TPEL.2016.2530745

DA9318 , 2017 . DA9318 Direct Charging Reference Board . Germany : Dialog Semiconductor . https://www.manualslib.com/manual/1634181/Dialog-Da9318.html https://www.manualslib.com/manual/1634181/Dialog-Da9318.html

Fardahar SM , Sabahi M , 2020 . New expandable switched-capacitor/switched-inductor high-voltage conversion ratio bidirectional DC-DC converter . IEEE Trans Power Electron , 35 ( 3 ): 2480 - 2487 . doi: 10.1109/TPEL.2019.2932325 http://doi.org/10.1109/TPEL.2019.2932325

Fei C , Ahmed MH , Lee FC , et al. , 2017 . Two-stage 48 V–12 V/6 V–1.8 V voltage regulator module with dynamic bus voltage control for light-load efficiency improvement . IEEE Trans Power Electron , 32 ( 7 ): 5628 - 5636 . doi: 10.1109/TPEL.2016.2605579 http://doi.org/10.1109/TPEL.2016.2605579

Jawalikar P , Patle N , Sahoo BD , 2020 . Time-domain modeling and analysis of switched-capacitor converters . IEEE Trans Power Electron , 35 ( 8 ): 8276 - 8286 . doi: 10.1109/TPEL.2020.2964263 http://doi.org/10.1109/TPEL.2020.2964263

Jong O , 2019 . Multi Resonant Switched-Capacitor Converters. MS Thesis , Virginia Polytechnic Institute and State University , Blacksburg, USA .

Lehmann T , 2014 . Design of fast low-power floating high-voltage level-shifters . Electron Lett , 50 ( 3 ): 202 - 204 . doi: 10.1049/el.2013.2270 http://doi.org/10.1049/el.2013.2270

Liu WL , Wang Z , Wang G , et al. , 2020 . Switched-capacitor-convertors based on fractal design for output power management of triboelectric nanogenerator . Nat Commun , 11 ( 1 ): 1883 . doi: 10.1038/s41467-020-15373-y http://doi.org/10.1038/s41467-020-15373-y

Liu ZD , Cong L , Lee H , 2015 . Design of on-chip gate drivers with power-efficient high-speed level shifting and dynamic timing control for high-voltage synchronous switching power converters . IEEE J Sol-State Circ , 50 ( 6 ): 1463 - 1477 . doi: 10.1109/JSSC.2015.2422075 http://doi.org/10.1109/JSSC.2015.2422075

Luo ZC , Ker MD , Cheng WH , et al. , 2017 . Regulated charge pump with new clocking scheme for smoothing the charging current in low voltage CMOS process . IEEE Trans Circ Syst I Reg Pap , 64 ( 3 ): 528 - 536 . doi: 10.1109/TCSI.2016.2619693 http://doi.org/10.1109/TCSI.2016.2619693

Meyvaert H , Piqué GV , Karadi R , et al. , 2015 . 20.1 A light-load-efficient 11/1 switched-capacitor DC-DC converter with 94.7% efficiency while delivering 100 mW at 3.3V . Proc IEEE Int Solid-State Circuits Conf , p. 1 - 3 . doi: 10.1109/ISSCC.2015.7063074 http://doi.org/10.1109/ISSCC.2015.7063074

Moghe Y , Lehmann T , Piessens T , 2011 . Nanosecond delay floating high voltage level shifters in a 0.35 μm HV-CMOS technology . IEEE J Sol-State Circ , 46 ( 2 ): 485 - 497 . doi: 10.1109/JSSC.2010.2091322 http://doi.org/10.1109/JSSC.2010.2091322

Mostacciuolo E , Vasca F , Baccari S , 2018 . Differential algebraic equations and averaged models for switched capacitor converters with state jumps . IEEE Trans Power Electron , 33 ( 4 ): 3472 - 3483 . doi: 10.1109/TPEL.2017.2702389 http://doi.org/10.1109/TPEL.2017.2702389

Palumbo G , Pappalardo D , 2010 . Charge pump circuits: an overview on design strategies and topologies . IEEE Circ Syst Mag , 10 ( 1 ): 31 - 45 . doi: 10.1109/MCAS.2009.935695 http://doi.org/10.1109/MCAS.2009.935695

Sanders SR , Alon E , Le HP , et al. , 2013 . The road to fully integrated DC-DC conversion via the switched-capacitor approach . IEEE Trans Power Electron , 28 ( 9 ): 4146 - 4155 . doi: 10.1109/TPEL.2012.2235084 http://doi.org/10.1109/TPEL.2012.2235084

Schaef C , Stauth JT , 2018 . A highly integrated series—parallel switched-capacitor converter with 12 V input and quasi-resonant voltage-mode regulation . IEEE J Emerg Sel Top Power Electron , 6 ( 2 ): 456 - 464 . doi: 10.1109/JESTPE.2017.2762083 http://doi.org/10.1109/JESTPE.2017.2762083

Schaef C , Rentmeister J , Stauth JT , 2018 . Multimode operation of resonant and hybrid switched-capacitor topologies . IEEE Trans Power Electron , 33 ( 12 ): 10512 - 10523 . doi: 10.1109/TPEL.2018.2806927 http://doi.org/10.1109/TPEL.2018.2806927

Seeman MD , Sanders SR , 2008 . Analysis and optimization of switched-capacitor DC–DC converters . IEEE Trans Power Electron , 23 ( 2 ): 841 - 851 . doi: 10.1109/TPEL.2007.915182 http://doi.org/10.1109/TPEL.2007.915182

Souvignet T , Allard B , Lin-Shi X , 2015 . Sampled-data modeling of switched-capacitor voltage regulator with frequency-modulation control . IEEE Trans Circ Syst I Reg Pap , 62 ( 4 ): 957 - 966 . doi: 10.1109/TCSI.2015.2399025 http://doi.org/10.1109/TCSI.2015.2399025

Xu M , Sun J , Lee FC , 2006 . Voltage divider and its application in the two-stage power architecture . Proc Twenty-First Annual IEEE Applied Power Electronics Conf and Exposition, Article 7 . doi: 10.1109/APEC.2006.1620584 http://doi.org/10.1109/APEC.2006.1620584

Yuan B , Ying J , Ng WT , et al. , 2020 . A high-voltage DC–DC buck converter with dynamic level shifter for bootstrapped high-side gate driver and diode emulator . IEEE Trans Power Electron , 35 ( 7 ): 7295 - 7304 . doi: 10.1109/TPEL.2019.2955310 http://doi.org/10.1109/TPEL.2019.2955310

Zhang F , Du L , Peng FZ , et al. , 2008 . A new design method for high-power high-efficiency switched-capacitor DC–DC converters . IEEE Trans Power Electron , 23 ( 2 ): 832 - 840 . doi: 10.1109/TPEL.2007.915043 http://doi.org/10.1109/TPEL.2007.915043

浏览量

Downloads

CSCD

文章被引用时，请邮件提醒。

Submit

工具集

关联资源

暂无数据