用于气动系统的一种改进型直接自适应鲁棒运动跟踪控制器

Peng-fei QIAN; Guo-liang TAO; De-yuan MENG; Hao LIU

doi:10.1631/jzus.C1400003

Your Location：

Home >

Browse articles >

用于气动系统的一种改进型直接自适应鲁棒运动跟踪控制器

电气与电子工程 | Updated：2022-05-19

- 用于气动系统的一种改进型直接自适应鲁棒运动跟踪控制器
- A modified direct adaptive robust motion trajectory tracking controller of a pneumatic system
- 信息与电子工程前沿（英文） 2014年15卷第10期页码：878-891
- Affiliations：
  
  1.The State Key Laboratory of Fluid Power Transmission and Control, Zhejiang University, Hangzhou 310027, China
  2.School of Mechatronic Engineering, China University of Mining and Technology, Xuzhou 221116, China
- Author bio：
  
  [ "Peng-fei QIAN, pengfeiqian@zju.edu.cn" ]
- Funds：
- DOI：10.1631/jzus.C1400003
  中图分类号： TH138;TP273
- 收稿：2014-02-05，
  
  修回：2014-;9-17，
  
  纸质出版：2014-10
- Accepted：
Scan QR Code
用于气动系统的一种改进型直接自适应鲁棒运动跟踪控制器[J]. 信息与电子工程前沿（英文）, 2014,15(10):878-891.

Peng-fei QIAN, Guo-liang TAO, De-yuan MENG, et al. A modified direct adaptive robust motion trajectory tracking controller of a pneumatic system[J]. Frontiers of Information Technology & Electronic Engineering, 2014, 15(10): 878-891.
用于气动系统的一种改进型直接自适应鲁棒运动跟踪控制器[J]. 信息与电子工程前沿（英文）, 2014,15(10):878-891. DOI： 10.1631/jzus.C1400003.

Peng-fei QIAN, Guo-liang TAO, De-yuan MENG, et al. A modified direct adaptive robust motion trajectory tracking controller of a pneumatic system[J]. Frontiers of Information Technology & Electronic Engineering, 2014, 15(10): 878-891. DOI： 10.1631/jzus.C1400003.

摘要

研究目的

采用直接自适应鲁棒控制器（DARC）时，可使用廉价开关电磁阀实现气动系统高精度运动轨迹跟踪控制。为简化DARC算法，本文提出一种改进型直接自适应鲁棒控制策略（modified DARC）。

创新要点

采用卡尔曼滤波器，估计合成确定性鲁棒控制律时的中间控制率的一阶导数，从而避免求解中间控制率的一阶导数的可计算部分，简化控制算法。

方法提亮

采用基于离散投影的梯度类型的自适应率，以确保估计出的未知模型参数落在已知有界区域内；使用确定性鲁棒控制策略减小未建模动态、扰动以及参数估计误差的影响；使用离散投影图，以同时合成参数自适应律和鲁棒控制律；分别设计卡尔曼滤波器，用于估计运动状态、估计合成确定性鲁棒控制律时的中间控制率的一阶导数。

重要结论

本文提出的改进型自适应鲁棒控制策略，可以简化控制算法。实验结果表明，该策略能实现高精度的运动轨迹跟踪控制，且对扰动有很强的鲁棒性。

Abstract

In this study

we developed and tested a high-precision motion trajectory tracking controller of a pneumatic cylinder driven by four costless on/off solenoid valves rather than by a proportional directional control valve. The relationship between the pulse width modulation (PWM) of a signal's duty cycle and control law was determined experimentally

and a mathematical model of the whole system established. Owing to unknown disturbances and unmodeled dynamics

there are considerable uncertain nonlinearities and parametric uncertainties in this pneumatic system. A modified direct adaptive robust controller (DARC) was constructed to cope with these issues. The controller employs a gradient type adaptation law based on discontinuous projection mapping to guarantee that estimated unknown model parameters stay within a known bounded region

and uses a deterministic robust control strategy to weaken the effects of unmodeled dynamics

disturbances

and parameter estimation errors. By using discontinuous projection mapping

the parameter adaptation law and the robust control law can be synthesized separately. A recursive backstepping technology is applied to account for unmatched model uncertainties. Kalman filters were designed separately to estimate the motion states and the derivative of the intermediate control law in synthesizing the deterministic robust control law. Experimental results illustrate the effectiveness of the proposed controller.

关键词

Keywords

references

K. Ahn , , , S. Yokota . . Intelligent switching control of pneumatic actuator using on/off solenoid valves . . Mechatronics , , 2005 . . 15 ( ( 6 ): ): 683 - - 702 . . DOI: 10.1016/j.mechatronics.2005.01.001 http://doi.org/10.1016/j.mechatronics.2005.01.001 . .

S. Aziz , , , G.M. Bone . . Automatic tuning of an accurate position controller for pneumatic actuators . . Proc. IEEE/RSJ Int. Conf. on Intelligent Robots and Systems , , 1998 . . p.1782 - - 1788 . . DOI: 10.1109/IROS.1998.724855 http://doi.org/10.1109/IROS.1998.724855 . .

E.J. Barth , , , M. Goldfarb . . A control design method for switching systems with application to pneumatic servo systems . . ASME Int. Mechanical Engineering Congress and Exposition , , 2002 . . p.463 - - 469 . . DOI: 10.1115/IMECE2002-33424 http://doi.org/10.1115/IMECE2002-33424 . .

E.J. Barth , , , J. Zhang , , , M. Goldfarb . . Sliding mode approach to PWM-controlled pneumatic systems . . Proc. American Control Conf. , , 2002 . . 3 2362 - - 2367 . . DOI: 10.1109/ACC.2002.1023995 http://doi.org/10.1109/ACC.2002.1023995 . .

X. Brun , , , M. Belgharbi , , , S. Sesmat , , , 等 . . Control of an electropneumatic actuator: comparison between some linear and non-linear control laws . . Proc. Inst. Mech. Eng. Part Ⅰ: J. Syst. Contr. Eng. , , 1999 . . 213 ( ( 5 ): ): 387 - - 406 . . DOI: 10.1243/0959651991540232 http://doi.org/10.1243/0959651991540232 . .

J.F. Carneiro , , , F.G. de Almeida . . A high-accuracy trajectory following controller for pneumatic devices . . Int. J. Adv. Manuf. Technol. , , 2012 . . 61 ( ( 1-4 ): ): 253 - - 267 . . DOI: 10.1007/s00170-011-3695-6 http://doi.org/10.1007/s00170-011-3695-6 . .

H.M. Chen , , , Z.Y. Chen , , , M.C. Chung . . Implementation of an integral sliding mode controller for a pneumatic cylinder position servo control system . . 4th Int. Conf. on Innovative Computing, Information and Control , , 2009 . . p.552 - - 555 . . DOI: 10.1109/ICICIC.2009.240 http://doi.org/10.1109/ICICIC.2009.240 . .

A. Girin , , , F. Plestan , , , X. Brun , , , 等 . . High-order sliding-mode controllers of an electropneumatic actuator: application to an aeronautic benchmark . . IEEE Trans. Contr. Syst. Technol. , , 2009 . . 17 ( ( 3 ): ): 633 - - 645 . . DOI: 10.1109/TCST.2008.2002950 http://doi.org/10.1109/TCST.2008.2002950 . .

S. Hodgson , , , M.Q. Le , , , M. Tavakoli , , , 等 . . Improved tracking and switching performance of an electropneumatic positioning system . . Mechatronics , , 2012 . . 22 ( ( 1 ): ): 1 - - 12 . . DOI: 10.1016/j.mechatronics.2011.10.007 http://doi.org/10.1016/j.mechatronics.2011.10.007 . .

H.K. Lee , , , G.S. Choi , , , G.H. Choi . . A study on tracking position control pneumatic actuators . . Mechatronics , , 2002 . . 12 ( ( 6 ): ): 813 - - 831 . . DOI: 10.1016/S0957-4158(01)00024-1 http://doi.org/10.1016/S0957-4158(01)00024-1 . .

D.Y. Meng , , , G.L. Tao , , , W. Ban , , , 等 . . Adaptive robust output force tracking control of pneumatic cylinder while maximizing/minimizing its stiffness . . J. Cent. South Univ. , , 2013a . . 20 ( ( 6 ): ): 1510 - - 1518 . . DOI: 10.1007/s11771-013-1642-4 http://doi.org/10.1007/s11771-013-1642-4 . .

D.Y. Meng , , , G.L. Tao , , , X.C. Zhu . . Integrated direct/indirect adaptive robust motion trajectory tracking control of pneumatic cylinders . . Int. J. Contr. , , 2013b . . 86 ( ( 9 ): ): 1620 - - 1633 . . DOI: 10.1080/00207179.2013.792002 http://doi.org/10.1080/00207179.2013.792002 . .

T. Nguyen , , , J. Leavitt , , , F. Jabbari . . Accurate sliding-mode control of pneumatic systems using low-cost solenoid valves . . IEEE/ASME Trans. Mechatron. , , 2007 . . 12 ( ( 2 ): ): 216 - - 219 . . DOI: 10.1109/TMECH.2007.892821 http://doi.org/10.1109/TMECH.2007.892821 . .

S. Ning , , , G.M. Bone . . Experimental comparison of two pneumatic servo position control algorithms . . Proc. IEEE Int. Conf. on Mechatronics and Automation , , 2005 . . p.37 - - 42 . . DOI: 10.1109/ICMA.2005.1626519 http://doi.org/10.1109/ICMA.2005.1626519 . .

P.F. Qian , , , G.L. Tao , , , J.F. Chen . . Modeling and simulation of stick-slip motion for pneumatic cylinder based on meter-in circuit . . Appl. Mech. Mater. , , 2012 . . 130-134 775 - - 780 . . DOI: 10.4028/www.scientific.net/AMM.130-134.775 http://doi.org/10.4028/www.scientific.net/AMM.130-134.775 . .

P.F. Qian , , , G.L. Tao , , , D.Y. Meng , , , 等 . . Nonlinear model-based position servo control of electro-pneumatic clutch actuator . . Trans. Chin. Soc. Agric. Mach. , , 2014 . . 45 ( ( 3 ): ): 1 - - 6 . . DOI: 10.6041/j.issn.1000-1298.2014.03.001 http://doi.org/10.6041/j.issn.1000-1298.2014.03.001 . .

Z. Rao , , , G.M. Bone . . Nonlinear modeling and control of servo pneumatic actuators . . IEEE Trans. Contr. Syst. Technol. , , 2008 . . 16 ( ( 3 ): ): 562 - - 569 . . DOI: 10.1109/TCST.2007.912127 http://doi.org/10.1109/TCST.2007.912127 . .

E. Richard , , , S. Scavarda . . Comparison between linear and nonlinear control of an electropneumatic servodrive . . J. Dynam. Syst. Meas. Contr. , , 1996 . . 118 ( ( 2 ): ): 245 - - 252 . . DOI: 10.1115/1.2802310 http://doi.org/10.1115/1.2802310 . .

R. Richardson , , , A.R. Plummer , , , M.D. Brown . . Self-tuning control of a low-friction pneumatic actuator under the influence of gravity . . IEEE Trans. Contr. Syst. Technol. , , 2001 . . 9 ( ( 2 ): ): 330 - - 334 . . DOI: 10.1109/87.911384 http://doi.org/10.1109/87.911384 . .

H. Schulte , , , H. Hahn . . Fuzzy state feedback gain scheduling control of servo-pneumatic actuators . . Contr. Eng. Pract. , , 2004 . . 12 ( ( 5 ): ): 639 - - 650 . . DOI: 10.1016/S0967-0661(03)00148-5 http://doi.org/10.1016/S0967-0661(03)00148-5 . .

X. Shen , , , J. Zhang , , , E.J. Barth , , , 等 . . Nonlinear model-based control of pulse width modulated pneumatic positioning system . . J. Dynam. Syst. Meas. Contr. , , 2006 . . 128 ( ( 3 ): ): 663 - - 669 . . DOI: 10.1115/1.2232689 http://doi.org/10.1115/1.2232689 . .

Z. Situm , , , D. Pavkovic , , , B. Novakovic . . Servo pneumatic position control using fuzzy PID gain scheduling . . J. Dynam. Syst. Meas. Contr. , , 2004 . . 126 ( ( 2 ): ): 376 - - 387 . . DOI: 10.1115/1.1767857 http://doi.org/10.1115/1.1767857 . .

M. Smaoui , , , X. Brun , , , D. Thomasset . . A study on tracking position control of an electropneumatic system using backstepping design . . Contr. Eng. Pract. , , 2006 . . 14 ( ( 8 ): ): 923 - - 933 . . DOI: 10.1016/j.conengprac.2005.05.003 http://doi.org/10.1016/j.conengprac.2005.05.003 . .

Y.C. Tsai , , , A.C. Huang . . Multiple-surface sliding controller design for pneumatic servo systems . . Mechatronics , , 2008 . . 18 ( ( 9 ): ): 506 - - 512 . . DOI: 10.1016/j.mechatronics.2008.03.006 http://doi.org/10.1016/j.mechatronics.2008.03.006 . .

R.B. van Varseveld , , , G.M. Bone . . Accurate position control of a pneumatic actuator using on/off solenoid valves . . IEEE/ASME Trans. Mechatron. , , 1997 . . 2 ( ( 3 ): ): 195 - - 204 . . DOI: 10.1109/3516.622972 http://doi.org/10.1109/3516.622972 . .

J. Wang , , , D.J.D. Wang , , , P.R. Moore , , , 等 . . Modelling study, analysis and robust servocontrol of pneumatic cylinder actuator systems . . IEE Proc.-Contr. Theory Appl. , , 2001 . . 148 ( ( 1 ): ): 35 - - 42 . . DOI: 10.1049/ip-cta:20010238 http://doi.org/10.1049/ip-cta:20010238 . .

G. Welch , , , G. Bishop . . An introduction to the Kalman filter . . SIGGRAPH, Course 8 , , 2001 . . .

F. Xiang , , , J. Wikander . . Block-oriented approximate feedback linearization for control of pneumatic actuator systems . . Contr. Eng. Pract. , , 2004 . . 12 ( ( 4 ): ): 387 - - 399 . . DOI: 10.1016/S0967-0661(03)00104-7 http://doi.org/10.1016/S0967-0661(03)00104-7 . .

L. Xu , , , B. Yao . . Adaptive robust precision motion control of linear motors with negligible electrical dynamics: theory and experiments . . IEEE/ASME Trans. Mechatron. , , 2001 . . 6 ( ( 4 ): ): 444 - - 452 . . DOI: 10.1109/3516.974858 http://doi.org/10.1109/3516.974858 . .

B. Yao . . Integrated direct/indirect adaptive robust control of SISO nonlinear systems in semi-strict feedback form . . Proc. American Control Conf. , , 2003 . . p.3020 - - 3025 . . DOI: 10.1109/ACC.2003.1243991 http://doi.org/10.1109/ACC.2003.1243991 . .

B. Yao , , , A. Palmer . . Indirect adaptive robust control of SISO nonlinear systems in semi-strict feedback forms . . Proc. 15th IFAC World Congress , , 2002 . . p.1050 DOI: 10.3182/20020721-6-ES-1901.01052 http://doi.org/10.3182/20020721-6-ES-1901.01052 . .

B. Yao , , , M. Tomizuka . . Smooth robust adaptive sliding mode control of robot manipulators with guaranteed transient performance . . Proc. American Control Conf. , , 1994 . . p.1176 - - 1180 . . DOI: 10.1109/ACC.1994.751934 http://doi.org/10.1109/ACC.1994.751934 . .

B. Yao , , , M. Tomizuka . . Adaptive robust control of SISO nonlinear systems in a semi-strict feedback form . . Automatica , , 1997 . . 33 ( ( 5 ): ): 893 - - 900 . . DOI: 10.1016/S0005-1098(96)00222-1 http://doi.org/10.1016/S0005-1098(96)00222-1 . .

B. Yao , , , F. Bu , , , J. Reedy , , , 等 . . Adaptive robust motion control of single-rod hydraulic actuators: theory and experiments . . IEEE/ASME Trans. Mechatron. , , 2000 . . 5 ( ( 1 ): ): 79 - - 91 . . DOI: 10.1109/3516.828592 http://doi.org/10.1109/3516.828592 . .

X.C. Zhu , , , G.L. Tao , , , B. Yao , , , 等 . . Adaptive robust posture control of a parallel manipulator driven by pneumatic muscles . . Automatica , , 2008 . . 44 ( ( 9 ): ): 2248 - - 2257 . . DOI: 10.1016/j.automatica.2008.01.015 http://doi.org/10.1016/j.automatica.2008.01.015 . .

浏览量

Downloads

CSCD

文章被引用时，请邮件提醒。

Submit

工具集

关联资源

Adaptive robust neural control of a two-manipulator system holding a rigid object with inaccurate base frame parameters

Event-triggered adaptive tracking control of a class of nonlinear systems with asymmetric time-varying output constraints

A fast integral sliding mode controller with an extended state observer for position control of permanent magnet synchronous motor servo systems

Steering control for underwater gliders

A robust object tracking framework based on a reliable point assignment algorithm#